高等学校化学学报 ›› 2017, Vol. 38 ›› Issue (11): 2118.doi: 10.7503/cjcu20170101

• 高分子化学 • 上一篇    下一篇

半互穿海藻酸钠/聚丙烯酰胺凝胶吸附结晶紫动力学/热力学行为和吸/脱附机理

李志刚1, 张艺璇1, 张青松1(), 马友伟2, 胡涛1, 白海会2, 刘鹏飞3, 王珂4, 张小勇4   

  1. 1. 天津工业大学材料科学与工程学院, 分离膜与膜过程国家重点实验室, 天津 300387
    2. 纺织学院, 天津 300387
    3. 计算机科学与软件学院, 天津 3003877
    4. 清华大学化学系, 北京 100084
  • 收稿日期:2017-02-22 出版日期:2017-11-10 发布日期:2017-10-30
  • 作者简介:联系人简介: 张青松, 男, 博士, 副教授, 博士生导师, 主要从事仿生高分子研究. E-mail: zqs8011@163.com
  • 基金资助:
    天津市应用基础与前沿技术研究计划项目(批准号: 12JCQNJC01400, 15JCYBJC18300)、 天津市科技特派员项目(批准号: 14JCTPJC00502, 15JCPJC62200)和全国大学生创新创业训练计划项目(批准号: 201510058005, 201510058051)资助

Adsorption Kinetics/Thermodynamic Behavior and Adsorption/Desorption Mechanism of Crystal Violet by Semi-interpenetrating Sodium Alginate/Polyacrylamide Hydrogel

LI Zhigang1, ZHANG Yixuan1, ZHANG Qingsong1,*(), MA Youwei2, HU Tao1, BAI Haihui2, LIU Pengfei3, WANG Ke4, ZHANG Xiaoyong4   

  1. 1. State Key Laboratory of Separation Membranes and Membrane Process,School of Material Science and Engineering, Tianjin 300387, China
    2. School of Textile, Tianjin 300387, China
    3. School of Computer Science & Software Engineering,Tianjin Polytechnic University, Tianjin 300387, China
    4. Department of Chemistry, Tsinghua University, Beijing 100084, China
  • Received:2017-02-22 Online:2017-11-10 Published:2017-10-30
  • Contact: ZHANG Qingsong E-mail:zqs8011@163.com
  • Supported by:
    † Supported by the Applied Basic Research and Advanced Technology Programs of Science and Technology Commission Foundation of Tianjin, China(Nos.12JCQNJC01400, 15JCYBJC18300), the Science and Technology Correspondent of Tianjin, China(Nos.14JCTPJC00502, 15JCPJC62200), and the National Training Programs of Innovation and Entrepreneurship for Undergraduates, China(Nos.201510058005, 201510058051)

摘要:

将含有大量—COO-的聚阴离子海藻酸钠(SA)引入聚丙烯酰胺(PAM)凝胶网络中, 采用自由基溶液聚合法制备半互穿网络结构的SA/PAM水凝胶. 采用扫描电子显微镜(SEM)、 X射线光电子能谱(XPS)和傅里叶变换红外光谱(FTIR)分析了SA/PAM水凝胶吸附结晶紫(CV)前后的孔洞形态和化学组成变化, 采用多种模型研究了SA/PAM水凝胶对CV分子的吸附动力学和热力学行为, 并探讨了脱附效率, 提出了吸脱附机理. 研究结果表明, SA的引入降低了孔径尺寸, 增加了孔洞数量; SA/PAM-10凝胶对CV分子吸附量最大, 达到13.5838 mg/g, 符合伪一级吸附动力学模型, 吸附速率受膜扩散和粒子内扩散过程共同影响; 等温吸附过程符合Temkin和D-R模型, 属于微孔多层吸附; 热力学分析结果表明, 吸附过程由熵驱动引起, 非化学诱导因素影响所致; 采用HCl进行脱附, 最大脱附率高达94.18%, 加入NaOH可实现SA/PAM水凝胶的可逆吸附; 较高的吸附量主要源于SA分子链上的COO-与CV分子的—C=N+—存在的静电作用, 低pH值时由于—COO-和—NH2质子化导致与CV分子的静电斥力增大, 脱附率随之增加.

关键词: 聚丙烯酰胺, 海藻酸钠, 结晶紫, 水凝胶, 吸附动力学

Abstract:

The sodium alginate(SA), a kind of polyanion electrolyte including many carboxylic acid(—COO-), was introduced into polyacrylamide hydrogel network to prepare the SA/PAM hydrogels with semi-interpenetrating network structure via free-radical solution polymerization. The pore morphology and chemical composition of SA/PAM hydrogels before and after adsorption of crystal violet(CV) were comparative analyzed by scanning electron microscope(SEM), X-ray photoelectron spectroscopy(XPS) and Fourier transform infrared spectroscopy(FTIR). All kinds of models were used to study adsorption kinetics and thermodynamics behavior for the adsorption of crystal violet(CV) on the SA/PAM hydrogel. Meanwhile, the desorption efficiency was discussed, and the mechanism of adsorption and desorption was proposed. The results showed that, with the introduction of SA, the pore size reduced, but pore numbers increased. The SA/PAM-10 hydrogel shows the maximum adsorption amount, about 13.5838 mg/g. Four kinds of SA/PAM hydrogels agree with pseudo first-order kinetic model, and the adsorption rate depends on both film diffusion and particle diffusion. The isothermal adsorption process is consistent with the Temkin and the D-R model, which belongs to the microporous multi-layer adsorption. Thermodynamic analysis results show that the adsorption process is driven by entropy rather than chemical factor. The desorption was achieved by adding HCl, the maximum desorption rate reached up to 94.18%, and reversible adsorption of SA/PAM hydrogel could be found by adding NaOH. The high adsorption capacity can be ascribed to the electrostatic interaction between COO- of SA molecular chain and —C=N+— of CV molecules. Due to protonation of —COO- and —NH2 under low pH value, leading to increased electrostatic repulsion with CV molecules. Accordingly, the desorption rate was naturally increased.

Key words: Polyacrylamide, Sodium alginate, Crystal violet, Hydrogel, Adsorption kinetics

中图分类号: 

TrendMD: