高等学校化学学报

高等学校化学学报 ›› 2003, Vol. 24 ›› Issue (8): 1499.

• 论文 • 上一篇    下一篇

丁二烯气相聚合的负载型稀土催化剂研究

张一烽, 倪旭峰, 李俊菲, 李维实, 沈之荃   

  1. 浙江大学高分子科学与工程系, 杭州 310027
  • 收稿日期:2002-08-08 出版日期:2003-08-24 发布日期:2003-08-24
  • 通讯作者: 张一烽(1941年出生),女,教授,博士生导师,从事可控聚合及有机硅新材料研究.
  • 基金资助:

    国家自然科学基金(批准号:20074029);国家重点基础研究(批准号:G1999064800);浙江省自然科学基金(批准号:200073)资助

Studies on the Supported Rare Earth Catalyst of Gas Phase Polymerization of 1,3-Butadiene

ZHANG Yi-Feng, NI Xu-Feng, LI Jun-Fei, LI Wei-Shi, SHEN Zhi-Quan   

  1. Department of Polymer Science and Engineering, Zhejiang University, Hangzhou 310027, China
  • Received:2002-08-08 Online:2003-08-24 Published:2003-08-24

PDF (PC)

被引次数

16

摘要： 合成了负载型稀土催化剂,并将其用于丁二烯气相聚合.研究表明,硅胶负载Nd(naph)3-Al(i-Bu)3-Al(i-Bu)2Cl催化体系具有相当高的催化活性和立体定向性,其最佳组成:n(Al)/n(Nd)=40～60,n(Cl)/n(Nd)=3～7.添加适量单体丁二烯或异戊二烯,尤其是添加丁二烯,可成倍提高催化活性,随着聚合反应的进行,其速率在10min内迅速增加并达到峰值,随后降低,动力学行为属衰减型.所得聚丁二烯的分子量在几十万至百万,凝胶含量小于6%,顺-1,4结构含量达到98%左右.

关键词: 负载型稀土催化剂, 异戊二烯, 丁二烯, 气相聚合

Abstract: The supported rare earth catalytic system was synthesized and used in the gas phase polymerization of 1,3-butadiene (Bd) successfully.It is found that the catalyst of silica gel supported Nd(naph)3-Al(i-Bu)3-Al(i-Bu)2Cl has a rather high catalytic activity and high sterospecificity.The catalytic system was found to have an excellent activity when n(Al)/n(Nd)=40-60, n(Cl)/n(Nd)=3-7. Adding a suitable amount of monomer, both Bd and isoprene(Ip) as seed in the preparation of catalyst can greatly increase the catalytic activity of the catalytic system, and Bd is found more effective.The polymerization rate increases rather rapidly and reaches the maximum within 10 min, then decreases slowly.The obtained p(Bd) has a molecule weight about 105-106with cis-1,4 structure above 98% and gel content less than 6%.

Key words: Supported rare earth catalyst, 1,3-Butadiene(Bd), Isoprene(IP) Gas phase polymerization

中图分类号: 

TrendMD: