以泡沫镍载NiCo2O4纳米线阵列为阴极催化剂的Al-H2O2半燃料电池

高等学校化学学报 ›› 2011, Vol. 32 ›› Issue (10): 2382.

以泡沫镍载NiCo2O4纳米线阵列为阴极催化剂的Al-H2O2半燃料电池

田永梅^1,2, 雷婷¹, 王贵领¹, 曹殿学¹

1. 哈尔滨工程大学材料科学与化学工程学院, 哈尔滨 150001;
2. 黑龙江大学化学化工与材料学院, 哈尔滨 150080

收稿日期:2010-10-08 修回日期:2011-03-04 出版日期:2011-10-10 发布日期:2011-09-11
通讯作者: 王贵领 E-mail:wangguiling@hrbeu.edu.cn
基金资助:
国家自然科学基金(批准号: 20973048)资助.

A Al-H2O2 semi fuel cell using Ni foam supported NiCo2O4 nanowire arrays as cathode

TIAN Yong-Mei^1,2, LEI Ting¹, WANG Gui-Ling^1*, CAO Dian-Xue¹

1. College of Material Science and Chemical Engineering, Harbin Engineering University, Harbin 150001, China;
2. School of Chemistry and Material s Science, Heilongjiang University, Harbin 150080, China

Received:2010-10-08 Revised:2011-03-04 Online:2011-10-10 Published:2011-09-11
Contact: WANG Gui-Ling E-mail:wangguiling@hrbeu.edu.cn
Supported by:
国家自然科学基金(批准号: 20973048)资助.

摘要/Abstract

摘要： 研究了以泡沫镍载NiCo2O4纳米线阵列为阴极催化剂的Al-H2O2半燃料电池的性能. 以无模板生长法制备了泡沫镍载NiCo2O4纳米线阵列阴极材料, SEM测定结果表明, NiCo2O4纳米线几乎垂直于泡沫镍载体表面生长. 以电压和功率密度-电流密度曲线研究了H2O2浓度、电解液流速和温度对电池性能的影响, 结果显示, 以铝片为阳极, 0.6 mol/L H2O2为氧化剂的电池的开路电压约为1.40 V; 在室温和57 ℃下, 电流密度为98和172 mA/cm2时, 最大功率密度分别达到79和120 mW/cm2. 在5000 s的测试时间内, 0.70 V的恒电流密度和75 mA/cm2 的恒电压值几乎为一常数, 这表明以泡沫镍载NiCo2O4纳米线阵列为催化剂电还原H2O2具有很好的活性、稳定性和传质性能.

关键词: 泡沫镍载NiCo2O4纳米线阵列, Al-H2O2半燃料电池, 阴极催化剂

Abstract: A Al-H2O2 semi-fuel cell using Ni foam supported NiCo2O4 nanowire arrays as cathode was reported. Ni foam supported-NiCo2O4 nanowire arrays were prepared by a template-free growth method, and demonstrated that NiCo2O4 nanowires grow almost vertically from the surface of foamed Ni substrate by scanning electron microscopy(SEM). The effects of concentrations of H2O2, flow rate of electrolyte as well as operation temperature on the cell performance were investigated. The cell exhibited an open circuit voltage of about 1.40 V; peak power densities of 79 and 120 mW/cm2 at current densities of 98 and 172 mA/cm2 and a cell voltage of 0.80 V and 0.70 V operating at room temperature and 320 K, respectively, using aluminium sheet as anode fuel and 0.6 mol/L H2O2 as oxidant. The current density at 0.7 V and voltage 75 mA/cm2 remained nearly constant within a 5000 s test period, the Ni foam supported NiCo2O4 nanowire arrays electrode exhibits superior activity, stability, and mass transport property for H2O2 electroreduction.

Key words: Ni foam supported NiCo2O4 nanowire array, Al-H2O2 semi-fuel cell, Cathode catalyst

中图分类号:

O646
TM911

TrendMD:

田永梅, 雷婷, 王贵领, 曹殿学. 以泡沫镍载NiCo2O4纳米线阵列为阴极催化剂的Al-H2O2半燃料电池. 高等学校化学学报, 2011, 32(10): 2382.

TIAN Yong-Mei, LEI Ting, WANG Gui-Ling*, CAO Dian-Xue. A Al-H2O2 semi fuel cell using Ni foam supported NiCo2O4 nanowire arrays as cathode. Chem. J. Chinese Universities, 2011, 32(10): 2382.

参考文献

[1] Yang W. Q., Yang S. H., Sun W., Sun G., Xin Q. J. Power Sources[J], 2006, 160:1420—1424 [2] Dow E. G., Bessette R. R., Seeback G. L., Orndorff M., Meunier H.., Zee J., Medeiros M. J. Power Sources[J], 1997, 65:207—212 [3] Bessette R. R., Cichon J. M., Dischert D. W., Dow E. J. Power Sources[J], 1999, 80:248—253 [4] Cao D.X., Chen D.D., Lan J., Wang G. J. Power Sources[J], 2009, 190:346—350 [5] TANG Ya-Wen(唐亚文), CAO Shuang(曹爽), CHEN Yu(陈煜), BAO Jian-Chun(包建春),LU Tian-Hong(陆天虹). Chem. J. Chinese Universities (高等学校化学学报)[J], 2007, 28(5): 936—939 [6] WANG Gui-Ling(王贵领), CHENG Yuan-Hui(程元徽), ZHANG Wei-Cai(张伟才), LU Tian-Hong(陆天虹), CAO Dian-Xue(曹殿学), LV Yan-Zhuo(吕艳卓), ZHANG Sen(张森). Chem. J. Chinese Universities (高等学校化学学报)[J], 2010, 31(1):153—156 [7] Savinova E. .R, Wasle S., Doblhofer K. Electrochimica Acta[J], 1998, 44:1341—1348 [8] Yang W. Q., Yang S. H., Sun W., Sun G. Q., Xin Q. Electrochim. Acta[J], 2006, 52: 9—14 [9] David J. B., John J. R. Applied Energy[J], 2003, 74:113—124 [10] Bessette R. R., Medeiros M. G., Patrissi C. J., Deschenes C. M., LaFratta C. N. Journal of Power Sources[J], 2001, 96:240—244 [11] Hasvold ?., St?rkersen N.J., Forseth Sissel., Lian T. Journal of Power Sources[J], 2006,162:935—942 [12] Hasvold ?., Johansen K. H., Mollestad O., Forseth S., St?rkersen N. Journal of Power Sources[J], 1999, 80:254—260 [13] Cao D., Wu L., Wang G. Journal of Power Sources[J], 2008, 183:799—804. [14] LI Feng(李峰), LIU Hai-Jing(刘海晶), WANG Yong-Gang(王永刚), Li Hui-Qiao(李会巧), XIA Yong-Yao(夏永姚). Chem. J. Chinese Universities (高等学校化学学报)[J], 2007, 28(11):2133—2137 [15] Cao D., Wu L., Sun Y., Wang G., Lv Y.. Journal of Power Sources[J], 2008, 177: 624—630. [16] GAO Yin-Yi(高胤义), CAO Dian-Xue(曹殿学), WANG Gui-Ling(王贵领), YIN Cui-Lei(尹翠蕾). Acta Phys.-Chim. Sin. (物理化学学报)[J], 2010, 26(1):29—33 [17] Cao D., Chao J., Sun L., Wang G. J. Power Sources[J], 2008, 179:87—91 [18] Wang G., Cao D., Yin C., Yin J., Cheng L. Chem. Mater. [J], 2009, 21:5112—5118 [19] Gao Y., Chen S., Cao D., Wang G., Yin J. J. Power Sources[J], 2010, 195:1757—1760. [20] Tang Y. G., Huang B. Y., Lu L. B., Liu D. R. Physics[J], 2004, 2: 85—89.